Current Issue

Stigmatized no more

Comments Email
TORONTO—It has taken rubberized asphalt more than 20 years to get over the onus placed on it by the Intermodal Surface Transportation Efficiency Act (ISTEA).

But now, it seems ready to take its place as a useful, widely respected technology and the potential market leader for recycled rubber.

This was the consensus of speakers at the 2012 Rubber Recycling Symposium late last year in Toronto, co-sponsored by the Rubber Association of Canada and the Rubber Manufacturers Association (RMA).

“The time is right for rubberized asphalt, because the price of conventional asphalt has gone up,” said RMA Vice President Michael Blumenthal.

Mr. Blumenthal said he expected to see significant growth in the rubberized asphalt market over the next two years, particularly with the establishment of the Rubberized Asphalt Foundation (RAF), a research foundation dedicated to the science of recycled tire rubber in asphalt.

Many of the board members of the RAF are university professors and state highway transportation officials, and much of the information it provides is from those disciplines, according to Mr. Blumenthal. “That gives the organization a lot more credibility than if it were a mere industry group,” he said.

Passed in 1991, the ISTEA included a provision that required state highway transportation agencies to include an ever-increasing percentage of rubberized asphalt in their road paving projects as a prerequisite for keeping their federal highway funds.

State highway officials resented the mandate and early tests with rubberized asphalt—done without the input of the rubberized asphalt industry—proved a failure.

Finally, Congress repealed the rubberized asphalt mandate, and to this day the industry has had to fight the bad impression the ISTEA provision created.

“It (rubberized asphalt) was ahead of its time,” said Doug Carlson, vice president-asphalt products at Liberty Tire Recycling L.L.C. “Rubber was more expensive than asphalt, and it had a different cost structure.”

The rising cost of conventional asphalt is not the only reason rubberized asphalt is gaining acceptance, according to Mr. Carlson. The material also is more resistant to cracking, has noise-dampening properties, provides better traction than conventional asphalt and can be laid in a thinner layer than conventional asphalt, he said.

Mr. Carlson showed cost comparisons between conventional asphalt and asphalt modified with recycled tire rubber. The latter today costs $520 a ton, compared with $550 a ton for the conventional material, he said.

The savings in maintenance costs over time are even more dramatic, he said.

Using figures from the Arizona Department of Transportation, Mr. Carlson showed that average maintenance costs for rubberized asphalt were $500 per lane mile over 10 years, compared with $1,400 per lane mile for conventional asphalt.

Canadian provincial highway agencies are very interested in rubberized asphalt, according to speakers at the symposium. However, the states with the greatest experience in using rubberized asphalt—Arizona, California, Florida—are all hot-weather areas and previous rubberized asphalt studies in the cold climate of Canada had varying success, they said.

There's no question rubberized asphalt is useful in cold climates because the Alaska Department of Transportation has successfully used it in highway projects for years, according to Gary Hicks, general manager of Hicks and Associates.

Mr. Hicks presented two papers at the symposium dealing with testing of rubber-modified asphalt and rubberized asphalt cement in Ontario.

A few formulations have had emissions problems in being tested, Mr. Hicks said, but most have had no major problems at all. “Warm mix” rubber additives extend the road construction season in Ontario and actually reduce emissions, he said.

Also, high-binder-content chip seals and interlayers have proved extremely durable and effective in resisting reflective cracking, Mr. Hicks said.
More Polls>

TB Reader Poll

Previous | Published February 1, 2019

What issue concerns you most heading into 2019?

The threat of more tariffs.
27% (27 votes)
The new Congress in Washington.
35% (35 votes)
Price fluctuations for the products we sell.
10% (10 votes)
More disruptions across the industry.
29% (29 votes)
Total votes: 101
More Polls »